sure star computer co., ltd no. 2-1, daan road, shulin dist., new taipei city 2 38, taiwan e-mail: info@surestar.com.tw tel: +886 2 26 82 2505 http: //www.surestar.com.tw fax: +886 2 2 682 2515 model:TC-2U40 (400w for 2u single) 1. specification 1.1 ac input voltage: 90 to 132 or 180 to 264 auto selectable 50 to 60 hz. 1.2 dc output: 400w maximum output-1 output-2 output-3 output-4 output-5 voltage: +5v dc +12v dc -5v dc -12v dc +3.3v dc maximum load: 40a 20a 0.3a 0.8a 20a minimum load: 3a 2a 0.1a 0.1a 0.3a ripple: 50mv 120mv 50mv 120mv 50mv ripple/noise: 100mv 150mv 100mv 240mv 50mv line regulation: 1 1 1 1 1 output regulation: 5 5 10 10 5 cross regulation: 5 5 10 10 5 note: 1. noise test C noise bandwidth is from dc to 20 mh z. 2. ripple frequencies greater than 1mhz shall be at tenuated by the measurement system. 3.add 0.1uf/10uf capacitor at output connector term inals for ripple and noise measurements. 4. the combined total power from 5v & 3.3v shall no t exceed 200w. the combined total power from +5v and +12v & +3.3 v shall not exceed 378w. 5. +5v sb dc output 2a. 1.3 ps-on remote on/off control: when ps-on is pulled to ttl low, the dc output is t o be enabled. when ps-off is pulled to ttl high, the dc output is to be disabled. 1.4 pw-ok pw-ok is power good signal and should be asserte d high by the power supply to indicate that +5vdc and +3.3vdc output are above the under voltage thresholds of the power supply ttl. comp atible signal out with 100ms to 500ms.
timing of ps-on, pw-ok, and germane vol tage rails although there is no requirement to meet specifi c timing parameters, the following signal timings are recommended: 2ms t2 200ms Q Q 100ms t3 500ms Q Q t4 1ms t5 10ms Q 1.5 efficiency: R 70 at full load.(normal line) 1.6 hold-up time: 16ms at maximum load & normal input voltage. 2. protections 2.1 over-voltage protection standard on +5.0v output, set at 6.25vdc 075v dc. 2.2 short circuit protection a short circuit placed between the dc return an d the output shall cause no damage and the power supply shall shutdown. 2.3 over power protection the power supply shall shut down when output po wer exceeds 130 to 160 of full load and require a power on cycle be pe rformed by the operate 2.4 no load operation no parts shall be damaged on the power supply. 3. environment temperature 3.1 operation temperature: 0 to 50 3.2 cooling: by forced air 3.3 storage temperature:-20 to 70 3.4 humidity: 5 to 90 non-condensing.
4. reliability 4.1 mtbf of power supply electronis 100,000 hours at full load and 25 ambient temperature 4.2 life expectancy of fan 40,000 hours at 40 5. agency approvals ul 1950 qqgq2 ul 1950 qqgq8 tuv rheinland ( en60950-1+a12; iec:60950 ) 6. emi fcc part 15, subpart b, class a en55022 cispr22 class a, en61000-3-3;1995 en61000-4-2, -3, -4, -5, -6, -11 7. dimension l 200 x w 100 x h 70 mm
8. pinouts of connectors atx or eps (20+4)pin x 1 , m8p +12v power connector x 1 , m4p +12v power connector x 1 , h.d.d. x 6 , floppy x 2. p24 14 16 15 17 13 18 19 21 20 22 23 24 1 2 4 35 9 78 6 11 12 10 purple(+3.3v) red(+5v) pin no. wire color pin no. orange(pg) brown(+5vsb) white(-5v) blue(-12v) yellow(+12v) gray(ps-on) wire color black(gnd) 560mm/18awg 560mm/22awg 560mm/18awg 560mm/20awg 560mm/18awg 560mm/18awg length length com com black 580mm 15mm length wire type signal wire color pin no. 3 4 2 1 18awg 18awg 18awg 18awg black yellow +12v yellow +12v 4pins(atx12v,for p4) connector housing: molex 39-01-0280 or equivalent terminal: molex 39-00-0060 or equivalent housing housing p4 560mm/18awg 560mm/18awg purple(+3.3v) purple(+3.3v) purple(+3.3vs) black(gnd) black(gnd) red(+5v) yellow(+12v) purple(+3.3v) black(gnd) black(gnd) black(gnd) black(gnd) black(gnd) red(+5v) red(+5v) red(+5v) 560mm/18awg 560mm/18awg 560mm/18awg 560mm/18awg 560mm/18awg connector housing: molex 39-01-2240 or equivalent 24pins(eps12v) terminal: molex 39-00-0039 or equivalent model no ? part no ? mm of date sheet ? draw no D? units draw by. LD check by. approve by. ? ? projection: material ? ?? : S : .x= .xx= .xxx= toleances: kevin sure star 2010,12,23 pin8 pin4 pin1 pin5 pin4 pin2 pin1 pin3 560mm/18awg 560mm/18awg 560mm/18awg 560mm/18awg 560mm/18awg 560mm/18awg 560mm/18awg 560mm/18awg 560mm/18awg 560mm/18awg 560mm/18awg connector housing: molex 39-01-0280 or equivalent 8pins(eps12v) 18awg 18awg 18awg 18awg 18awg 18awg 18awg 18awg 1 2 4 3 5 com +12v 7 8 6 pin no. wire color signal wire type length black black 580mm 15mm black black yellow yellow yellow yellow com com com +12v +12v +12v terminal: molex 39-00-0060 or equivalent housing p8 p8 p4 pin13 pin1 pin12 pin24 p24 l=580mm15mm l=580mm15mm l=560mm15mm 03 tc-1u30.35 harness 560mm/18awg
model no ? part no ? mm of date sheet ? draw no D? units draw by. LD check by. approve by. ? ? projection: material ? ?? : S : .x= .xx= .xxx= toleances: kevin sure star 2010,12,23 03 tc-1u30.35 harness pin4 pin3 pin2 pin1 pin4 pin3 pin2 pin1 l=150mm 15mm l=480mm15mm p4h2 p4h1 pin4 pin1 pin4 pin3 pin2 pin1 p4f1 p4h3 p4h4 pin4 pin3 pin2 pin1 l=150mm 15mm l=150mm 15mm l=480mm15mm pin4 pin1 pin4 pin3 pin2 pin1 p4f2 p4h5 p4h6 pin4 pin3 pin2 pin1 l=150mm 15mm l=150mm 15mm l=480mm15mm terminal:amp 60619-4 or equivalent 4pins(hd/cd-rom/rw):p4h1~p4h6 com length wire size signal wire color pin no. 3 4 2 1 18awg 18awg 18awg 18awg black red +12v yellow black com +5v connector housing: amp 480424-0 or equivalent p4h1 housing com 3 4 2 1 18awg 18awg 18awg 18awg black red +12v yellow black com +5v p4h2 com 3 4 2 1 black red +12v yellow black com +5v p4f1 com 4 2 1 black red +12v yellow black com +5v p4h3 150mm 15mm 480mm 15mm terminal: amp 170262-2 or equivalent 4pins(floppy disk):p4f connector housing: amp 171822-4 or equivalent 18awg 18awg 18awg 18awg com 150mm 15mm 3 4 2 1 black red +12v yellow black com +5v p4h4 18awg 18awg 18awg 18awg p4h5 150mm 15mm 22awg 22awg 22awg 22awg com 3 4 2 1 black red +12v yellow black com +5v 18awg 18awg 18awg 18awg 480mm 15mm 480mm 15mm p4h6 com 4 2 1 black red +12v yellow black com +5v p4f2 150mm 15mm 22awg 22awg 22awg 22awg com 3 4 2 1 black red +12v yellow black com +5v 18awg 18awg 18awg 18awg 150mm 15mm 3 note: specification and wiring diagram subject to c hange without notice.
|
