IRDC3624eval rev 1.0 03/11/2006 1 user guide for ir3624 evaluation board usingirf8910 so-8 dual mosf et and 2x 22uf ceramic output capacitors description the ir3624 ic is a synchronous buck controller, providing a cost-effective, high performance and flexible solution. key features offered by the ir3624 include programmable soft start ramp, fixed 600khz switching frequency requiring no external components and input under-voltage lockout for proper start up. an output over-current protection function is implemented by sensing the voltage developed across the on-resistance of the synchronous rectifier mosfet for optimum cost and performance. jp1 v in ( +12v) ground jp2 v out ( +1.8v) ground this user guide contains the schematic and bill of materials for the ir3624 evaluation board. the guide describes operation and use of the evaluation board itself. detailed application information for the ir3624 integrated circuit is available in the ir3624 data sheet. evaluation board specifications: v in = +12v, (13.2v max) v out = +1.8v @ 6a connections: j1 lx (induct or input node) ground downloaded from: http:///
IRDC3624eval rev 1.0 03/11/2006 2 connection diagram figure 1 C connection diagram of evaluation board for ir3624 12v power supply 1.8v@ 0a to 6a ( 0.3 ohm or larger load resistor ) downloaded from: http:///
IRDC3624eval rev 1.0 03/11/2006 3 layout the pcb is 4-layer fr4 board. the ir3624 ic, the switching mosfets, and the associated passive components are mounted on the top side of the board. the bottom layer is used primarily for the signal and power grounds. the single point of connection between the signal ground and the power ground is located on the bottom layer. figure 2 C top and bottom layers of the ir3624 evaluation board. power supply decoupling capacitors, the charge pump capacitor and feedback components are located close to the ir3624 ic. the feedback resistors are connected to the output voltage at the point of regulation and are located close to the ic. single point of connectionbetween analog ground and power ground the switch mosfet and the synchronous rectifier mosfet are packaged together in a single so-8 footprint device. the input and output energy storage capacitors and the power inductor are located close to the mosfet package. to improve efficiency, the circuit board is designed to minimize the length of the on- board power ground current path. breaks in the solder mask are provided to allow easy soldered connections to external power supply and load devices. downloaded from: http:///
IRDC3624eval rev 1.0 03/11/2006 4 layout - grounds the two mid-layers are used primarily for analog and power ground. the two grounds are kept separated from each other. they are connected at a single point on the bottom layer as shown in figure 2. figure 3 C internal layers of ir3624 evaluation board. v out sense point mid-layer 1 mid-layer 2 signal ground power ground power ground downloaded from: http:///
IRDC3624eval rev 1.0 03/11/2006 5 figure 4 C schematic of th e ir3624 evaluation board downloaded from: http:///
IRDC3624eval rev 1.0 03/11/2006 6 bill of materials ref desig value description qty part# source u1 buck synchronous controller, 10 lead mlpd 1 ir3624mpbf international rect ifier q1 20v ,13.4mohm mosfet 1 irf8910 international rectifier d1 schottky sot-23 dual diode 1 bat54sct international rectifier l1 0.82uh inductor 1 sts703-r82m act c9 10uf, 25v, x5r, eia, 1210 1 ecj4yb1e106m panasonic c11, 12 22uf,6.3v,x5r, eia 0805 2 ecj2fboj226m panasonic c4 3900pf,50v,x5r eia 0603 1 ecj-1vb1h392k panasonic c3 100pf, 50v np0 eia 0603 1 ecj-1vb1h101j panasonic c7 330pf, 50v np0 eia 0603 1 ecj-1vc1h331j panasonic c10 1 uf, 16v x5r eia 0603 1 ecj-1vb1c105k panasonic c1, 2 0.1 uf, 16v y5v eia 0603 2 ecj-1vf1c104z panasonic c5, 6 0.1 uf, 50v y5v eia 0603 2 ecj-1vf1h104z panasonic r1 0 ohm eia 0603 1 any r3 5.11 kohm eia 0603 1 any r8 28.0 kohm eia 0603 1 any r9 14.0 kohm eia 0603 1 any r10 2.00 kohm eia 0603 1 any r11 9.09 kohm eia 0603 1 any jp1, 2 2-wire terminal block 2 ed1973-nd digi-key pcb circuit board 1 rje3624u-v1cr0 international rectifier none adhesive rubber foot 4 sj67-a2 3m "bumpon" c14 eia 0603 unused r2 eia 0603 unused r6 eia 0603 unused r7 eia 0603 unused j1 o-scope-probe tip jack unused 131-5031-00 tektronix downloaded from: http:///
IRDC3624eval rev 1.0 03/11/2006 7 typical operating waveforms vin=13.2v, vo=1.8v, io=0-6a, fs=600 khz, room temperature, no air flow fig.5: start up at 6a load ch 1 :v in , ch 2 :v ss , ch 3 :v o fig.9: transient response ch 1 :v o , ch4:i step (0-3a) fig.7: output voltage ripple at 6a load ch 1 : v o , ch 2 :inductor point (l x ) fig.6: pre-bias start up ch 1 :v in , ch 2 :v ss , ch 3 :v o fig.8: gate signals at 6a load ch 1 :hdrv, ch 2 :lx, ch 3 :ldrv fig.10: shorted output, hiccup condition ch 1 :v o , ch 2 :v ss , ch 4 :i o downloaded from: http:///
IRDC3624eval rev 1.0 03/11/2006 8 typical operating waveforms vin=13.2v, vo=1.8v, io=0-6a, fs=600 khz, room temperature, no air flow fig.11: bode plot at 10%of load shows a bandwid th of 70khz and phase margin of 62 degree fig.12: efficiency at room temperature, no air flow ir3624, 600 khz 12v to 1.8v 50 55 60 65 70 75 80 85 01234567 io(a) efficiency (%) downloaded from: http:///
IRDC3624eval rev 1.0 03/11/2006 9 ir world headquarters: 233 kansas st., el segundo, california 90245, usa tel: (310) 252-7105 tac fax: (310) 252-7903 this product has been designed and qualified for the industrial market. visit us at www.irf.com for sales contact information data and specifications subject to change without notice. 02/01 (ir3624m) mlpd package 3x3-10lead seating plane leads on 2 sides d e e/2 d2 e2 a (nd-1) x e e l a1 a3 b e d e2 d2 l a a1 m o b s y b a3 l nd n nom inches .008 ref .118 bsc .118 bsc .016 .055 _ min .000 millimeters nom min max .035 .032 .0008 veed-5 0.80 0.90 1.00 0.00 0.02 0.05 1.40 _ 1.75 .0071 0.30 .0098 0.18 0.25 0.20 ref 2.70 2.20 _ .087 3.00 bsc 3.00 bsc 0.40 0.30 0.50 .012 0.50 pitch 5 10 .068 .039 .0019 max .0118 .106 .019 10 .020 pitch 5 e _ terminal 1 identifier 1 1 1 tape & reel orientation figure a downloaded from: http:///
|
